power supply

This is the place for any magazine-related discussions that don't fit in any of the column discussion boards below.
Post Reply
dinrough
Posts: 1
Joined: Thu Mar 03, 2005 1:01 am
Contact:

power supply

Post by dinrough » Thu Mar 03, 2005 9:53 am

I have 2 APC9258 KVM switches that both suffer from the same problem, the power supply has blown a zenner diode (NTE137A
# ZENER DIODE-6.2 VOLT, 1 WATT)I replaced it w/ the same part, but the power supply still does not work properly.
I took a known good power supply and checked the voltages, i get +12v, gnd, -5v on the outputs (ironically, this is a slightly different design where the zenner is not present, but still same output). On the repaired power supply, i get +7v, gnd, -5v.
I suspect a TL431 9B1 voltage regulator to be the culprit.
Can anyone give me some pointers on where to look. I am pretty much an newbe to 120v ac electronic circuits, but reasonably familiar in the 12v dc automotive area.

User avatar
sofaspud
Posts: 531
Joined: Wed Feb 13, 2002 1:01 am
Location: San Antonio, TX
Contact:

Re: power supply

Post by sofaspud » Thu Mar 03, 2005 3:47 pm

I'm not familiar with the specific equipment or regulator you have, but...
If that is a regulated +7 volts you are getting than the TL431 is likely to be good. Is the input voltage to the regulator of sufficient amplitude? It also seems possible that a support component(s) common to the zener and regulator has gone bad, causing the zener failure and the 5 volt output error.
You can check the regulator by lifting the input pin and applying a variable DC voltage while monitoring the output.

Enzo
Posts: 276
Joined: Tue Sep 14, 2004 1:01 am
Location: Lansing, Michigan, USA
Contact:

Re: power supply

Post by Enzo » Thu Mar 03, 2005 4:57 pm

Are these actually constructed with the NTE diode in them, or is that the sub you looked up? What is the original part that was blown? Your 7v looks suspiciously like one junction drop above the 6.2v.

Post Reply

Who is online

Users browsing this forum: No registered users and 66 guests